|British Rail Class 67|
|Sources: except where noted|
The Class 67 locomotives are a class of Bo-Bo diesel-electric locomotives which were built for the English Welsh & Scottish Railway (EWS) between 1999 and 2000 by Alstom at Meinfesa in Valencia, Spain with drive components (engine, generator and traction motors) from General Motors' Electro-Motive Division.
EMD's designation for this locomotive type is JT42HW-HS.
Design, testing and introduction
EWS ordered thirty locomotives via leasing company Angel Trains in a £45million contract split between Alstom and Electro Motive Diesel, for use as Class 47 replacements for hauling high-speed Royal Mail trains and passenger trains. The locomotives were obtained on a 15-year lease from Angel Trains. At the end of the fifteen-year contract, ownership of the locomotives was transferred to DB Cargo UK.
The bodyshell is a monocoque load bearing Alstom design, the bogies are an "H" frame Alstom design, the engine, traction motors and control electronics are GM-EMD products, and the same as used in the Class 66. Unlike the Class 66, the traction motors are frame mounted rather than axle hung to reduce unsprung mass and the gear ratio is increased allowing higher speeds. The cab design has a central driving position.
The locomotives are able to supply Electric Train Supply for passenger train heating and air-conditioning, and are equipped for buffer and screw coupling and also coupling via a buckeye coupler attached on a swing arm mount.
High speed running tests were undertaken with 67002 starting at Alstom's facility at La Sagra (Toledo, Spain) and running on the standard gauge Madrid-Toledo high-speed rail line. A top speed of 143 miles per hour (230 km/h) was obtained.
The first locomotive to be delivered was 67003, which arrived in October 1999. Initially plans were for a rapid acceptance into service, but problems with the locomotives being slightly out of loading gauge caused delays. Acceptance trials began in December, and all 30 units had been delivered to the UK by early 2000.
The high axle load of the locomotive caused an initial speed restriction to 110 mph (177 km/h) and modifications to the bogies were required; locomotive 67023 was passed for 125 mph (201 km/h) running in July 2001, and all 30 units had been modified by June 2003.
DB Cargo UK
The locomotives have since been used by First ScotRail on the Caledonian Sleeper on non-electrified lines north of Edinburgh. In April 2015, GB Railfreight commenced a contract to haul the Caledonian Sleeper with 67004 repainted and renamed for use on the service. When GB Railfreight started to provide the trains and crews for the Serco franchise in 2015, it was planned to use rebuilt Class 73/9s. The first of these came into service in February 2016. But the Class 67s continued to be used on some services for another couple of years.
Class 67s are also used as Thunderbird rescue locomotives, for failed trains on the East Coast Main Line, on some freight trains, and for use on chartered tourist trains. Two locomotives were assigned to, and received special liveries for use with the Royal Train from 2003, and a third had a commemorative jubilee livery applied for use with the Royal Train during the Diamond Jubilee of Elizabeth II in 2012.
Chiltern Railways began using ex-Wrexham & Shropshire Class 67 hauled passenger sets in December 2010, in September 2011 after improvements to the Chiltern Main Line infrastructure, Chiltern began running a 100 mph (160 km/h) service from London to Birmingham branded Mainline using Class 67 powered sets. Chiltern Railways leased six Class 68s from December 2014, to replace Class 67s on its Chiltern Main Line services.
|Class||Number built (year)||Operator||Number||TOPS number range|
|Class 67||30 (1999-2000)||DB Cargo UK||28||67001-67022|
|Colas Rail||2||67023, 67027|
Locomotives that do not currently carry their names are shown with the name in brackets.
|67001||(Night Mail)||DB Cargo UK||Arriva Blue||In service|
|67002||(Special Delivery)||Involved in a serious crash at Lawrence Hill, Bristol in November 2000.|
|67003||Arriva Blue||Stored||Stored October 2019|
|67004||Cairn Gorm (Post Haste)||DB Cargo UK Red||In service|
|67005||Queen's Messenger||Royal Claret|
|67007||EWS Maroon & Gold||Stored||Stored October 2019|
|67008||EWS Maroon & Gold||In service|
|67009||EWS Maroon & Gold||Stored||Stored October 2016|
|67010||(Unicorn)||DB Cargo UK Red||In service|
|67011||EWS Maroon & Gold||Stored||Stored June 2016|
|67012||(A Shropshire Lad)||Wrexham & Shropshire Silver||In service|
|67013||(Dyfrbont Pontcysyllte)||DB Cargo UK Red|
|67014||(Thomas Telford)||Transport for Wales Red & White|
|67015||(David J Lloyd)||DB Cargo UK Red|
|67016||EWS Maroon & Gold|
|67017||Arrow||Transport for Wales Red & White|
|67018||Keith Heller||DB Cargo UK Red with Maple Leaf||Stored||Stored March 2019|
|67019||EWS Maroon & Gold||Stored March 2015|
|67020||EWS Maroon & Gold||In service|
|67021||Belmond British Pullman Brown & Cream|
|67022||EWS Maroon & Gold||Stored||Stored June 2019|
|67023||Stella||Colas Rail||Colas Rail Yellow & Orange||In service|
|67024||DB Cargo UK||Belmond British Pullman Brown & Cream|
|67025||(Western Star)||Transport for Wales Red & White|
|67026||Diamond Jubilee||Jubilee Silver||Stored||Stored June 2016|
|Colas Rail||Colas Rail Yellow & Orange||In service|
|67028||DB Cargo UK||DB Cargo UK Red|
|67029||Royal Diamond||DB Cargo UK Silver|
|67030||Schenker||EWS Maroon & Gold||Stored||Stored October 2019|
Liveries and namings
The locomotives were initially painted in EWS's maroon and yellow livery. In 2003, 67005 and 67006 replaced the two previous Class 47 locomotives hauling the Royal Train. These were repainted in the Royal Claret colour and named Queen's Messenger and Royal Sovereign, respectively, in December 2000 and February 2005.
In October 2004, 67029 was repainted silver, with full bodyside height EWS logos, to haul the EWS Company Train. On 12 October 2007, 67029 was named Royal Diamond at Rugeley Trent Valley railway station, in honour of the 60th wedding anniversary of Queen Elizabeth II and Prince Philip.
In 2008, 67012–67015 were repainted in Wrexham & Shropshire's silver and grey livery. In 2008, these were named A Shropshire Lad (3 July), Dyfrbont Pontcysyllte (9 July), Thomas Telford (14 July) and David J Lloyd (16 May), respectively. These were joined by 67010 in March 2009, to add resilience to the sub-fleet. The sub-fleet was dispersed at the end of 2014, with locomotives receiving further repaints appropriate to their new roles.
In January 2010, 67018 was repainted into DB Schenker red with a maple leaf and named Keith Heller at the National Railway Museum. in honour of the Canadian-born former EWS and DB Schenker UK chairman.
In March 2012, 67026 received a silver livery, union flag and Diamond Jubilee logo for use during the Diamond Jubilee of Elizabeth II celebrations, being named Diamond Jubilee by Queen Elizabeth II on 23 March at London Victoria station.
In March 2015, 67004 received the Caledonian 'Midnight Teal' livery and was named Cairn Gorm. This, along with similarly repainted 67010, was used on the non-electrified parts of the Serco Caledonian Sleeper until the release of sufficient Class 73/9s for use by GB Railfreight. Both 67004 and 67010 have since been repainted into DB Cargo red livery, and are now both operational (67004 being stored for nearly two years).
In June 2017 Colas Rail duo 67023 and 67027 received the names Stella and Charlotte, respectively, on nameplates carried centrally on the bodysides.
19/20 October 2017 saw 67021 and 67024 rolled out in (unbranded) Belmond British Pullman umber and cream livery, receiving Belmond British Pullman logos a few months later.
In October 2018 the Royal locomotives, 67005 and 67006 were repainted into a slightly revised version of the Royal claret livery.
A serious crash occurred with 67002 at Lawrence Hill (Bristol) on 1 November 2000, when a Royal Mail train passed two red signals and ran into the back of a coal train at around 3:30am. The mail train, hauled by 67002 "Special Delivery" with 67012 at the rear, was travelling at 50 miles per hour (80 km/h) when the incident occurred. The locomotive climbed over the back of the coal train, coming to rest 40 yards (37 m) later on top of a coal wagon and against the A420 Church Road bridge. The driver of the mail train suffered a broken arm and cuts to the face and chest, but there were no other injuries. The incident was initially suspected to be caused by faulty brakes but was later found to be caused by misunderstanding and incorrect use of the locomotive's brake pipe isolation valve by railway staff.
- The Israel Railways JT 42BW and RENFE Class 333.3 are a similar design
- Vossloh Euro 4000 - Related locomotives built at the same factory (former Alstom Valencia plant)
References and sources
- "Class 67 Diesel Photo Gallery - Class Info". class67.co.uk. The Class 67 Diesel Photo Web Site / Colin Birch.
- "Mainline Diesel-Electric Locomotives Class 67" (PDF). Vossloh-Eespana.com. Archived from the original (PDF) on 17 July 2011. Retrieved 4 March 2018.
- "Technical". The67Depot.Webs.com. The 67 Depot. Archived from the original on 30 August 2011.
- Waller, Mike (December 2010). Skips for Hire. p. 14.
- "JT42HW-HS". Main Line Diesels. Retrieved 5 November 2016.
All thirty units were ordered via leasing company Angel Trains Ltd. and subsequently leased on a fifteen-year contract to DB Schenker Rail UK (formerly EWS). At the end of the contract, ownership of the locomotives was transferred to DB Schenker Rail UK, which is now known as DB Cargo UK.
- The Railway magazine, Volume 150. IPC Business Press. 2004. p. 12.
- "Class 67". semgonline.com. Southern E-Group.
- "Class 67". therailwaycentre.com. The RailwayCentre.Com Ltd.
- Gareth McMurray. "rolling stock : class 67". www.thejunction.org.uk. Archived from the original on 11 November 2009.
- "EWS completes 125mph locomotive upgrade programme". ews-railway.co.uk. EWS. 26 June 2003. Archived from the original on 23 February 2004.
- Hume, Charlie. "North Wales Coast Railway: Class 67". nwrail.org.uk.
- "Mail trains to be scrapped". news.bbc.co.uk. BBC News. 6 June 2003.
- Butcher, Louise (13 April 2010). "Railways: Royal Mail services, 2003-" (PDF). House of Commons Library.
- GB Railfreight boosts rail services business with Serco Caledonian Sleeper contract Europorte 17 February 2015
- "Rebuilt 73/9s take over all Caledonian Sleeper work" Rail issue 805 20 July 2016 page 32
- "HML morning sleeper"  Steven Crozier, Flikr 30 June 2018
- Julian Holland (2007). Amazing and Extraordinary Railway Facts. David & Charles. p. 81. ISBN 9780715325827.
- "New Royal Train locomotive unveiled". ews-railway.co.uk. EWS. 18 February 2004. Archived from the original on 1 October 2006.
- "HM The Queen names dedicated Royal Train locomotive at Bristol". ews.railway.co.uk. EWS. 25 February 2005. Archived from the original on 1 October 2006.
- "DB Schenker Allocate a Third Locomotive for Diamond Jubilee Royal Train Use". Rail.co.uk. Atos IT Services UK Limited. 26 March 2012. Retrieved 24 April 2012.
- "Royal Train starts its Diamond Jubilee tour with specially commissioned locomotive". Rail.DBSchenker.co.uk. UK: DB Schenker Rail. 23 March 2012.
- Milner, Chris (26 January 2011). "Wrexham & Shropshire to cease operation". RailwayMagazine.co.uk. The Railway Magazine.
- Gareth Bayer (14 December 2010). "Chiltern commences Birmingham loco-hauled". RailExpress.co.uk. Rail Express.
- "Chiltern introduces its new 'Mainline' timetable" (PDF). Railway Herald (282): 4. 5 September 2011.
- "Chiltern Railways Launch 'Mainline' Silver Service Between London, Banbury and Birmingham". rail.co.uk. 2011.
- "Chiltern to lease six Class 68 locomotives from DRS". Railway Herald. 10 April 2014.
- "Chiltern leases six Class 68 locos for Mainline services in £15m deal". RailTechnologyMagazine.com. 15 April 2014.
- "[GB] Chiltern Railways Chooses Class 68 in Favour of Class 67". MainlineDiesels.net. 10 April 2014.
- Clark, Rhodri (May 2012). "Class 67 Haulage in Wales". Modern Railways. p. 84.
- "Power by the Hour" Rail Express April 2017
- "Bright outlook for Colas Class 67s released by Toton". The Railway Magazine. April 2017. p. 91.
- "Queen names 67005 Queen's Messenger" Rail issue 399 27 December 2000 page 13
- Rail Magazine (499): 22. 27 October 2004. Missing or empty
- Rail Magazine (577): 17. 24 October 2007. Missing or empty
- News Archive March 2008 wnxx.com
- News Archive April 2008 wnxx.com
- Rail Magazine (597): 68. 30 July 2008. Missing or empty
- News Archive March 2009 wnxx.com
- "First DB-Schenker liveried Class 67 named Keith Heller" (PDF). Railway Herald (208): 4. January 2010.
- Derek Porter. "Old Pictures of the Day - October 2011". therailwaycentre.com. Picture of the Day 6 October 2011.
- "Notes and News". Cardiff and Avonside Railway Society. January 2001. Retrieved 15 October 2015.
01/11 Disaster at Lawrence Hill! Services already affected by the weather were subject to further delays when the previous nights 5V17 23.48 Bristol Parkway-Barton Hill formed of 8 RES empty vans and top n' tailed by 67002 Special Delivery and 67012...
- Marston, Paul; Savill, Richard (2 November 2000). "Runaway mail train hits coal wagons". The Daily Telegraph. Retrieved 2 January 2014.
- Falconer, Adrian (1 November 2000). "67002". Flickr.
- "Driver escapes unhurt in Bristol train crash". The Guardian. Guardian Media Group. 1 November 2000. Retrieved 3 January 2014.
- "Hornby BR Class 67". Hornby Railways Collector Guide. Retrieved 1 February 2020.
- Fox, Peter; Hall, Peter; Pritchard, Robert (2004). British Railways Locomotives & coaching stock 2004. Sheffield: Platform 5. ISBN 1-902336-39-9.
- Waller, Mike (December 2010). "Skips for Hire" (PDF). The Marlow Donkey. Marlow & District Railway Society (131): 13–16., some minor inaccuracies in article
|Wikimedia Commons has media related to British Rail Class 67.|