G-VIIO, the aircraft involved, photographed in 2009
|Date||8 September 2015|
|Summary||Uncontained engine failure on ground, fire|
|Site||McCarran International Airport, Las Vegas, Nevada, United States |
|Aircraft type||Boeing 777-236ER|
|IATA flight No.||BA2276|
|ICAO flight No.||BAW2276|
|Call sign||SPEEDBIRD 2276|
|Flight origin||Las Vegas McCarran International Airport|
|Destination||Gatwick Airport, Crawley, England|
British Airways Flight 2276 was a scheduled international passenger service from Las Vegas to London. On 8 September 2015, the Boeing 777 operating the flight suffered an uncontained engine failure and fire in the left (#1) GE90 engine during take-off from Las Vegas-McCarran International Airport, prompting an aborted take-off and the evacuation of all passengers and crew. All 170 people on board survived, but 20 were injured. The aircraft, which suffered moderate damage to a section of its forward fuselage as of a result of the vigorous fire, returned to passenger service in March 2016.
The aircraft left Terminal 3, Gate E3, at 15:53 local time, and began its take-off from Runway 07L at 16:12 where the incident occurred.
After noticing what the pilot later described as a "catastrophic failure of the engine" well before take-off speed, the flight crew aborted the take-off by using the aircraft's brakes and ordered an evacuation of the aircraft. All 170 passengers and crew escaped. Nineteen people sustained minor injuries and one person sustained serious injuries. The aircraft is thought to have reached a speed of approximately 90 miles per hour (78 kn; 140 km/h) when the decision to abort was made; far below the takeoff decision speed of the aircraft, which would have been at least 139 miles per hour (121 kn; 224 km/h).
The airport's emergency services extinguished the fire within five minutes of the mayday call. Fourteen people were lightly injured, mostly from sliding down the escape chutes, and treated at Sunrise Hospital & Medical Center. The fire caused a large hole in the cargo hold and damage to the engine.
The Federal Aviation Administration (FAA) indicated the fire was caused by failure of the left General Electric GE90 engine, one of two fitted on the aircraft. The aircraft came to a halt upwind, causing the fire to be blown towards the fuselage; the aircraft sustained localised, but major, structural damage as a result. The aircraft was equipped with suppression systems, though the systems did not extinguish the fire.
The runway, one of four, was closed for four hours, and several inbound flights were cancelled.
The aircraft involved in the incident was a Boeing 777-236ER, s/n 29320, registered as G-VIIO. At the time of the incident, the aircraft was 16 years old; it had been delivered new to British Airways on 26 January 1999.
In December 2015, British Airways announced that a team of engineers from Boeing had assessed the aircraft and determined the damage was limited and suitable for repair. As a result, it was announced that the aircraft would be repaired and returned to service. A team from Boeing completed the repairs in February 2016.
Airworthiness tests were conducted on the aircraft on 25 February 2016. G-VIIO was flown to Victorville the following day, where it was repainted. The aircraft was then flown to Cardiff on 15 March for a routine C check. Finally, it returned to its London Gatwick base and resumed passenger service on 24 March.
The National Transportation Safety Board (NTSB), the American air accident investigative body, dispatched four investigators to the site the day after the incident. As well as FAA, Boeing and General Electric involvement, the British Air Accidents Investigation Branch has a representative and that representative has appointed "British Airways and the UK Civil Aviation Authority as technical advisors". Initial NTSB findings were that an uncontained engine failure had occurred and that the "left engine and pylon, left fuselage structure and inboard left wing airplane were substantially damaged by the fire". On 6 October 2015, the NTSB issued an update stating that the accident was traced to the failure of the "stage 8–10 spool in the high-pressure compressor section...liberating fragments that breached the engine case and cowling". The NTSB released their final report 2 years and 10 months later, the cause of the accident was determined as "The failure of the left engine high-pressure compressor (HPC) stage 8-10 spool, which caused the main fuel supply line to become detached from the engine main fuel pump and release fuel, resulting in a fire on the left side of the airplane. The HPC stage 8-10 spool failed due to a sustained-peak low-cycle fatigue crack that initiated in the web of the stage 8 disk; the cause of the crack initiation could not be identified by physical inspection and stress and lifing analysis. Contributing to this accident was the lack of inspection procedures for the stage 8 disk web."
- American Airlines Flight 383 (2016) - Caught fire at O'Hare Airport.
- Korean Air Flight 2708 – Another Boeing 777 that experienced an engine fire at Haneda Airport.
- Singapore Airlines Flight 368 – Boeing 777 aircraft that suffered an engine fire on 27 June 2016.
- BOAC Flight 712
- British Airtours Flight 28M
- TWA Flight 843
- Saudia Flight 163
- "NTSB Issues Update on the British Airways Engine Fire at Las Vegas". NTSB. Retrieved 10 September 2015.
- "Flight Info". FlightStats. Retrieved 9 September 2015. (Login required)
- Phipps, Claire. "British Airways plane catches fire at Las Vegas airport". The Guardian. Retrieved 9 September 2015.
- "13 hospitalized after British Airways fire in Las Vegas". Fox 5 Vegas. Archived from the original on 2 March 2016. Retrieved 9 September 2015.
- "National Transportation Safety Board Aviation Accident Final Report". National Transportation Safety Board. 19 June 2018. Retrieved 20 June 2018.
- "What happened to BA Flight 2276?". ITV News. Retrieved 23 February 2016.
- B777-200ER Dispatch Performance Data, The Boeing Company, 26 October 2017
- "British Airways fire: Jet's suppression system didn't work, source says". CNN. 9 September 2015. Retrieved 9 September 2015.
- Alcock, Charles (8 September 2015). "Engine Failure Causes Fire on British Airways Boeing 777". AIN Online. Retrieved 9 September 2015.
- Waldron, Greg. "Unclear whether BA 777 engine failure was contained". flightglobal.com. Retrieved 9 September 2015.
- Kaminski-Morrow, David (9 September 2015). "Weather data suggests crosswind at time of BA 777 fire". Flightglobal. Retrieved 9 September 2015.
- "Accident: British Airways B772 at Las Vegas on Sep 8th 2015, rejected takeoff due to engine fire". The Aviation Herald. Retrieved 9 September 2015.
- "Boeing 777 (G-VIIO)— British Airways". Plane Finder Data. Retrieved 3 October 2015.
- Velotta, Richard N. (16 December 2015). "British Airways jet that caught fire before takeoff at McCarran to fly again". Las Vegas Review-Journal. Retrieved 16 December 2015.
- "The Latest: Fire-damaged British Airways jet departs Vegas" Archived 23 May 2016 at WebCite. Associated Press via Las Vegas Sun. 26 February 2016. Retrieved 26 February 2016."Archived copy". Archived from the original on 23 May 2016. Retrieved 2016-05-23.CS1 maint: Archived copy as title (link)
- "British Airways B777-200ER G-VIIO Leaves Las Vegas". The BA Source. 26 February 2016. Retrieved 26 February 2016.
- "NTSB Investigators to Probe Engine Fire on British Airways 777 in Las Vegas". NTSB. Retrieved 9 September 2015.
- "NTSB Issues Second Update on British Airways Engine Fire at Las Vegas". NTSB. Retrieved 7 October 2015.